M A T E R I A L S A F E T Y D A T A S H E E T
Cold Process Cement - Free Page: 1
PRODUCT NAME: Cold Process Cement - Free HMIS CODES: H F R P
PRODUCT CODE: #78 AF
================== SECTION I - MANUFACTURER IDENTIFICATION =================
MANUFACTURER'S NAME: KARNAK CORPORATION
ADDRESS : 330 CENTRAL AVE.
CLARK, N.J. 07066
EMERGENCY PHONE : (800)424-9300 DATE PRINTED : 08/20/97
INFORMATION PHONE : (732)388-0300 NAME OF PREPARER : N/A
========== SECTION II - HAZARDOUS INGREDIENTS/SARA III INFORMATION =========
VAPOR PRESSURE WEIGHT
REPORTABLE COMPONENTS CAS NUMBER mm Hg @ TEMP PERCENT
--------------------------------------------------------------------------------------
ASPHALT 8052-42-4 .1 68 60-70
OSHA PEL: 5 MG/M3,
ACGIH TLV: 5 MG/M3, OTHER: N/A
MINERAL SPIRITS 8032-32-4 2 68 25-35
OSHA PEL: 100 PPM,
ACGIH TLV: 100 PPM, OTHER: N/A
AMORPHOUS ALUMINA SILICATES 93763-70-3 N/A N/A 2-7
OSHA PEL: 15 MG/M3
ACGIH PEL: 10 MG/M3
CELLULOSE FIBERS 9004-34-6 N/A N/A 2-7
OSHA PEL: 5 MG/M3,
ACGIH TLV: 5 MG/M3, OTHER: N/A
WATER 7732-18-5 23.7 77 .5-3
OSHA PEL: N/A,
ACGIH TLV: N/A, OTHER: N/A
HYDROUS ALUMINUM SILICATES 1302-78-9 N/A N/A < 1
OSHA PEL: 5 MG/M3,
ACGIH TLV: 5 MG/M3, OTHER: N/A
FATTY ACIDS AND ROSIN ACIDS 8016-81-7 NEG 20C < 1
OSHA PEL: N/A,
ACGIH TLV: N/A, OTHER: N/A
ALIPHATIC POLYAMIDES TRADE SECRET < 1 77 < 1
OSHA PEL: N/A,
ACGIH TLV: N/A, OTHER: N/A
*** No toxic chemical(s) subject to the reporting requirements of section 313 of
Title III and of 40 CFR 372 are present. ***
=============== SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS ============
BOILING RANGE: 315 F SPECIFIC GRAVITY (H2O=1): 0.97
VAPOR DENSITY: HEAVIER THAN AIR EVAPORATION RATE: SLOWER THAN ETHER
SOLUBILITY IN WATER: NEGLIGIBLE.
APPEARANCE AND ODOR: BLACK PASTE, MILD SOLVENT ODOR.
================= SECTION IV - FIRE AND EXPLOSION HAZARD DATA ==============
FLASH POINT: 107 F METHOD USED: PMCC
FLAMMABLE LIMITS IN AIR BY VOLUME- LOWER: 1 UPPER: 6
EXTINGUISHING MEDIA: FOAM, CO2, DRY CHEMICAL, WATER FOG
SPECIAL FIREFIGHTING PROCEDURES
POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS (SCBA) AND STRUCTUAL
FIREFIGHTERS PROTECTIVE CLOTHING WILL PROVIDE LIMITED PROTECTION.
UNUSUAL FIRE AND EXPLOSION HAZARDS
FLAMMABLE/COMBUSTIBLE MATERIAL; MAY BE IGNITED BY HEAT, SPARKS OR FLAMES. VAPORS
MAY TRAVEL TO A SOURCE OF IGNITION AND FLASH BACK.
CONTAINERS MAY EXPLODE IN HEAT OF FIRE. VAPOR EXPLOSION HAZARD INDOORS, OUTDOORS
OR IN SEWERS. RUNOFF TO SEWER MAY CREATE FIRE OR EXPLOSION HAZARD.EXPLOSION HAZARD.
======================== SECTION V - REACTIVITY DATA =======================
STABILITY: STABLE
CONDITIONS TO AVOID
M A T E R I A L S A F E T Y D A T A S H E E T
Cold Process Cement - Free Page: 2
EXTREME HEAT, OPEN FLAME.
INCOMPATIBILITY (MATERIALS TO AVOID)
ISOLATE FROM OXIDIZERS, HEAT AND OPEN FLAME.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
FIRE MAY PRODUCE IRRITATING OR POISONOUS GASES.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
==================== SECTION VI - HEALTH HAZARD DATA =======================
INHALATION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL OR RESPIRATORY IRRITATION,
DIZZINESS, FATIGUE, NAUSEA, HEADACHE, AND POSSIBLE UNCONSCIOUSNESS.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
CAN CAUSE SEVERE IRRITATION, REDNESS, TEARING, BLURRED VISION.
SKIN ABSORPTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
SKIN - PROLONGED OR REPEATED CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, AND DIARRHEA.
HEALTH HAZARDS (ACUTE AND CHRONIC)
ACUTE - HEADACHE, DIZZINESS, NAUSEA, IRRITATION. CHRONIC - LOSS OF APPETITE, NOSE BLEEDS.
CARCINOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: No OSHA REGULATED: No
N/A
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
PRE-EXISTING EYE, SKIN, OR RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE.
EMERGENCY AND FIRST AID PROCEDURES
MOVE VICTIM TO FRESH AIR AND CALL EMERGENCY MEDICAL CARE; IF NOT BREATHING,
GIVE ARTIFICIAL RESPIRATION; IF BREATHING IS DIFFICULT,
GIVE OXYGEN. IN CASE OF CONTACT WITH MATERIAL, IMMEDIATELY FLUSH EYES WITH RUNNING
WATER FOR AT LEAST 15 MINUTES. WASH SKIN WITH SOAP AND WATER. REMOVE AND ISOLATE
CONTAMINATED CLOTHING AN SHOES AT THE SITE.
=========== SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE ============
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
SMALL LEAKS: TAKE UP WITH SAND OR OTHER NONCOMBUSTIBLE ABSORBENT MATERIAL AND PLACE
INTO CONTAINERS FOR LATER DISPOSAL. LARGE LEAKS:
DIKE FAR AHEAD OF LIQUID SPILL FOR LATER DISPOSAL. STOP LEAK IF YOU CAN DO IT
WITHOUT RISK.
WASTE DISPOSAL METHOD
INCINERATE UNDER SAFE CONDITIONS OR DISPOSE OF IN ACCORDANCE WITH LOCAL STATE AND
FEDERAL REGULATIONS.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
DO NOT BREATHE VAPORS, USE WITH ADEQUATE VENTILATION. DO NOT TAKE INTERNALLY.
DON'T GET IN EYES. WEAR IMPERVIOUS CLOTHING. KEEP AWAY FROM HEAT AND FLAME.
OTHER PRECAUTIONS
SHUT OFF IGNITION SOURCES; NO FLAMES, SMOKING OR FLAMES IN HAZARD AREA.
===================== SECTION VIII - CONTROL MEASURES ======================
RESPIRATORY PROTECTION
WEAR RESPIRATOR IN CONFINED AREA.
VENTILATION
LOCAL EXHAUST RECOMMENDED.
M A T E R I A L S A F E T Y D A T A S H E E T
Cold Process Cement - Free Page: 3
PROTECTIVE GLOVES
NORMAL WORK GLOVES.
EYE PROTECTION
SAFETY GLASSES OR GOGGLES.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
EYE BATH AND SAFETY SHOWER.
WORK/HYGIENIC PRACTICES
WASH HANDS BEFORE EATING OR USING RESTROOM. SMOKE ONLY IN APPROVED AREAS.
========================= SECTION IX - DISCLAIMER ==========================
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE. HOWEVER,
NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING TO THE ACCURACY OF THIS DATA OR THE
RESULTS TO BE OBTAINED FROM THE USE THEREOF. KARNAK ASSUMES NO RESPONSIBILITY FOR
PERSONAL INJURY OR PROPERTY DAMAGE TO VENDEES, USERS OR THIRD PARTIES CAUSED BY
THE MATERIAL.
|